Product ID:611 MIILDLY ACTIVATED ROSIN FLUX
MSDS Date:01/06/1999
FSC:3439
NIIN:00-069-5815
MSDS Number: CJDGT

R & D METALS & CHEMICALS INC

201 PERIMETER PK SUITE C
KNOXVILLE, TN 37922-2233
US

Emergency Phone: 615-531-6065/800-645-7476

Info Phone: 615-531-6065

Cage: 56406

R & D METALS & CHEMICALS, INC

22533 KNOXVILLE, TN 37922-2233 US

Telephone: 423-531-2044

Cage: 56406

ISOPROPYL ALCOHOL

CAS: 67-63-0

RTECS: NT8050000

OSHA PEL 980 MG/M3;400 PPM

ACGIH TLV: 983 MG/M3;400 PPM

ROSIN

CAS: 8050-09-7

RTECS: VL0480000

OSHA PEL 0.01 MG/M3

ACGIH TLV: 0.01 MG/CUM

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: SKIN: PROLONGED OR REPEATED
SKIN CONTACT CAN CAUSE DEFATTING AND DERMATITIS. EYES: MAY CAUSE
SEVERE IRRITATION, TEARING, BLURRED VISION. INGESTION: ASPIRATION
HAZARD IF SWALLOWED. CAN CAUSE GAS TROINTESTINAL TRACT IRRITATION,
NAUSEA, VOMITING, AND DIARRHEA. INHALATION: EXPOSURE TO ROSIN FUME
MAY CAUSE DIZZINESS AND HEADACHE. MAY ALSO CAUSE AN ALLERGIC
REACTION SUCH AS RASH OR THROAT AND RESP IRATORY IRRITATION IN A
SENSITIVE PERSON. CHRONIC: OVEREXPOSURE TO ISOPROPYL ALCOHOL HAS
BEEN SUGGESTED AS A POSSIBLE CAUSE OF KIDNEY DAMAGE IN HUMAN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:DIZZINESS, IRRITATION, HEADACHE, TEARING,
BLURRED VISION, RASH, NAUSEA, VOMITING, DIARRHEA.
Medical Cond Aggravated by Exposure:PREEXISTING DISEASES OF THE EYES,
SKIN, RESPIRATORY TRACT, KIDNEY MAY BE AGGRAVATED BY OVEREXPOSURE
TO THIS PRODUCT.

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALATION: IF
AFFECTED, REMOVE INDIVIDUAL TO FRESH AIR. IF BREATHING IS
DIFFICULT, ADMINISTER OXYGEN. EYES: IMMEDIATELY FLUSH WITH PLENTY
OF WATER, LIFTING UPPER AND LOWER LIDS OCCASIONALLY. GET MEDICAL
ATTENTION. SKIN: WASH EXPOSED AREA WITH SOAP AND WATER. REMOVE
CONTAMINATED CLOTHING. INGESTION: CALL PHYSICIAN OR POISON CONTROL
CENTER IMMEDIATELY. NEVER GI VE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.

Flash Point Method:TCC
Flash Point:=17.C, 62.6F
Lower Limits:2.0
Upper Limits:12.0
Extinguishing Media:CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SELF CONTAINED BREATHING
APPARATUS IN ENCLOSED AREA.
Unusual Fire/Explosion Hazard:NONE

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. ELIMINATE SOURCES
OF IGNITION. VENTILATE AREA. ADD NON-FLAMMABLE ABSORBENT SUCH AS
SAND, VERMICULITE AND SCOOP INTO APPROPRIATE CONTAINER. TRANSFER TO
HOOD AND EVAPORATE OR SEAL FOR WASTE DISPOSAL.

Handling and Storage Precautions:STORE IN A COOL, DRY, VENTILATED AREA
AWAY FROM IGNITION SOURCES. KEEP CONTAINER CLOSED WHEN NOT IN USE.
READ ALL CONTAINER LABELLING. AVOID THE USE OF BRASS DRUM SPIGOTS.
USE POLYETHYLENE, POLYPROPY LENE, TEFLON, OR STAINLESS STEEL.
Other Precautions:FLAMMABLE. SINCE EMPTY CONTAINERS MAY RETAIN PRODUCT
RESIDUES (VAPOR, LIQUID, OR SOLID), ALL LABELED HAZARD PRECAUTIONS
MUST BE OBSERVED. KEEP OUT OF REACH OF CHILDREN. AVOID BREATHING
VAPORS. DO NOT GET IN EYE, ON SKIN OR ON CLOTHING. FOR INDUSTRIAL
USE ONLY. DO NOT TAKE INTERNALLY.

Respiratory Protection:NONE REQUIRED WHERE ADEQUATE VENTILATION
CONDITIONS EXIST. IF THRESHHOLD LIMIT VALUE IS EXCEEDED, WEAR A
NIOSH-APPROVED ORGANIC VAPOR RESPIRATOR.
Ventilation:MECHANICAL (GENERAL) AND/OR LOCAL EXHAUST, EXPLOSION-PROOF
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:RUBBER, NEOPRENE OR PLASTIC.
Eye Protection:CHEMICAL SPLASH GOGGLES IN COMPLIANCE WITH OSHA APPROVED
RESPIRATORS ADVISED.
Other Protective Equipment:EYE BATH, WASHING FACILITY, EMERGENCY
SHOWER, LAB COAT.
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH AFTER HANDLING AND BEFORE EATING,
DRINKING OR SMOKING.
Supplemental Safety and Health

HCC:F2
Boiling Pt:=82.2C, 180.F
B.P. Text:(760 MM HG)
Vapor Pres:33 (MM HG AT 20 DEG C)
Vapor Density:1
Spec Gravity:0.896 (H20=1) @ 77F
Evaporation Rate & Reference:2.8
Solubility in Water:SLIGHT.
Appearance and Odor:CLEAR, AMBER COLORED LIQUID; NON-RESIDUAL ODOR.
Percent Volatiles by Volume:63% BY WT.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:SPARKS, HEAT, OPEN FLAMES.
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE, CARBON
DIOXIDE.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL,
STATE, AND FEDERAL LAWS AND REGULATIONS. DESTROY BY APPROVED
INCINERATION OR DEPOSIT IN APPROVED LANDFILL.

SARA Title III Information:NONE
Federal Regulatory Information:TSCA: ALL INGREDIENTS OF THIS PRODUCT
ARE LISTED ON THE TSCA INVENTORY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.